2016 Harley Davidson Road King Parts Manual
We provide Harley-Davidson motorcycle service manuals. 2016 (30) 2017 (31) 2018 (26). Road King (31) Roadster (10). Repair Manuals include Factory Harley-Davidson (OEM) Manuals and aftermarket. Soft, tail, sturgis, road king, wide. Wiring, diagram, 2017, 2016, 2015. Toyota Camry Hybrid 2016 Service Manual. BikeBandit.com offers thousands of 2016 Harley-Davidson FLHR Road King parts to repair or restore your 2016 Harley-Davidson FLHR Road King to original factory condition and increase its resale value.
• Removing or altering factory installed parts can adversely affect performance and could result in death or serious injury. (00001a) Use only Harley-Davidson approved parts and accessories. Use of certain other manufacturer's performance parts will void your new motorcycle warranty. See your Harley- Davidson dealer for details.
• Do not store motorcycle with gasoline in tank within the home or garage where open flames, pilot lights, sparks or electric motors are present. Gasoline is extremely flammable and highly explosive, which could result in death or serious injury. (00003a) Engine exhaust from this product contains chemicals known to the State of California to cause cancer, and birth defects or other reproductive harm. • (00009a) When carrying passengers, it is your responsibility to instruct them on proper riding procedures. (See Riding Tips for Motorcyclist included in your Harley-Davidson Owner's Kit.) Do not allow other individuals, under any circumstances, to operate your motorcycle unless you know they are experienced, licensed riders and are thoroughly familiar with the operation of your particular motorcycle. • Replace punctured or damaged tires.
In some cases, small punctures in the tread area may be repaired from within the demounted tire by a Harley-Davidson dealer. Speed should NOT exceed 50 mph (80 km/h) for the first 24 hours after repair, and the repaired tire should NEVER be used over 80 mph (130 km/h). • Wash hands after handling. (00019e) Consult a Harley-Davidson dealer regarding any questions or problems that occur in the operation of your motorcycle. Failure to do so can aggravate an initial problem, cause costly repairs, cause an accident and could result in death or serious injury.
• Accessories and Cargo Harley-Davidson Motor Company cannot test and make specific recommendations concerning every accessory or combination of accessories sold. Therefore, the rider must be responsible for safe operation of the motorcycle when installing accessories or carrying additional weight. See the Accessory and Cargo section in your Owner's Manual. Improper loading of cargo or installation of accessories can affect motorcycle stability and handling, which could result in death or serious injury. • (00022a) Large surfaces such as fairings, windshields, back rests, and luggage racks can adversely affect handling. Only genuine Harley-Davidson items designed specifically for the motorcycle model should be used with proper installation.
• An abbreviated V.I.N. Is stamped on the left side crankcase at the base of the rear cylinder. NOTE: Always give the full 17-digit Vehicle Identification Number when ordering parts or making any inquiry about your motorcycle.
Typical Harley-Davidson V.I.N.: 2009 Touring Models Harley-Davidson V.I.N. Breakdown: 2009 Touring Models POSITION DESCRIPTION. • CODE MODEL CODE MODEL ® ® ® FLHR Road King FLHTCU Ultra Classic Electra Glide ® ® ® ® FLHTCU Ultra Classic Electra Glide with FLHTCU Ultra Classic Electra Glide sidecar Shrine ® ® FLTR Road Glide FLHT Electra Glide ®.
• Specifications Specifications: 2009 Touring Models Engine: 2009 Touring Models ITEM SPECIFICATION Number of cylinders 2 Type 4-cycle, 45 degree V-Type, air cooled Compression ratio 9.2-1 Bore 3.750 in. 95.25 mm Stroke 4.380 in. 111. Introductory Mathematics For Engineering Applications Solutions Manual there. 25 mm Displacement 96.00 cu.
Cm Torque (North 92.60 ft-lbs @ 125.57 Nm @. • DRIVE ITEM NUMBER OF TEETH Primary Engine Clutch Final Transmission Rear wheel Capacities: 2009 Touring Models ITEM U.S. LITERS Fuel tank (total) 6.00 gal 22.71 Low fuel warning light on 1.00 gal 3.79 Oil tank with filter 4.00 qt.
3.79 Transmission 1.00 qt. • Tire Sizes: 2009 Touring Models MODEL MOUNT SIZE NUMBER FLHRC front 16 in. D407F 130/90 B16 All models except FLHRC front 17 in. D407F 130/80 B17 All models rear 16 in. D407 180/65 B16 2009 vehicles use Dunlop Harley-Davidson tires only. • Bulb Chart: 2009 Touring Models LAMP DESCRIPTION BULBS CURRENT HARLEY- DRAW DAVIDSON (ALL LAMPS 12 VOLT) REQUIRED AMPERAGE PART NUMBER Headlamp FLHT/C/U, FLHR/C, FLHX 1 4.58/5.0 68329-03 FLTR 4.58/5.0 68329-03 Position lamp, 0.32 53438-92 international Position lamp, FLTR 0.32 53436-97 Japan Tail and stop Tail/stop lamp.
• (00024a) Tubeless tires fitted with the correct size inner tubes may be used on all Harley-Davidson laced (wire spoked) wheels. Protective rubber rim strips must be used with tubeless tires (fitted with correct size inner tubes) when mounted on laced (wire spoked) wheels. • Reformulated gasolines use additives to oxygenate the gas. Your motorcycle will run normally using this type of gas and Harley-Davidson recommends you use it when possible, as an aid to cleaner air in our environment. • Do not operate catalytic converter-equipped vehicle with engine misfire or a non-firing cylinder. If you operate the vehicle under these conditions, the exhaust will become abnormally hot, which can cause vehicle damage, including emission control loss.
(00149a) Use only unleaded fuel in catalytic converter-equipped motorcycles. Using leaded fuel will damage the emission control system. • (00043a) Some features explained are unique to certain models. These features may be available as accessories for your Harley-Davidson motorcycle.
See a Harley-Davidson dealer for a complete list of accessories that will fit your specific motorcycle. Ignition/Headlamp Key Switch: Touring Models The automatic-on headlamp feature provides increased visibility of the rider to other motorists. • The lamps illuminate when the switch is in the IGNITION position, as required by law in some localities.
Ignition/Headlamp Switch Positions: Touring Models MODEL FUNCTION LABEL OPERATION FLHT Key Lock LOCK Locks the switch in either the FORK LOCK or ACCESS switch position. • See Fork Lock: FLHR/FLHRC. On FLHR/FLHRC models, the fork lock is located at the top of the steering head, behind the headlamp nacelle and inset in the handlebar clamp shroud. See Ignition/Headlamp Key Switch: Touring Models. On FLHT/FLTR/FLHX models, the fork lock is integrated into the ignition switch. • See Basic Handlebar Controls: FLHRC Shown (typical). The electric starter switch is located on the right handlebar control group.
See Starting the Engine for detailed operation procedures. Put the engine off/run switch in the RUN position and the transmission in neutral. Neutral (green) indicator lamp should be illuminated. • left handlebar and is operated with the fingers of the left hand.
Slowly pull clutch hand lever in against handlebar grip to fully disengage clutch. Shift to first gear using the gear shifter lever. See Cruise Control: Touring Models. Slowly release the clutch hand lever to engage clutch.
A clutch switch is incorporated into the left handlebar switch assembly. • Clutch hand lever Horn switch Headlamp dimmer switch Left turn signal switch Master cylinder reservoir Electric starter switch Engine off/run switch Brake hand lever Throttle control grip Throttle friction adjusting screw (not shown, not used on cruise control models) Right turn signal switch Basic Handlebar Controls: FLHRC Shown (typical) Electronic Throttle Control (ETC) Touring models are equipped with Electronic Throttle Control (ETC). • Hazard Warning 4-Way Flasher Use the following method to activate the four-way flashers.
With the ignition key ON and security system disarmed (if equipped), press the left and right turn signal switches at the same time. Turn the ignition key OFF and arm the security system if present and desired. The four-way flashers will continue for two hours. • Speedometer Travel at speeds appropriate for road and conditions and never travel faster than posted speed limit. Excessive speed can cause loss of vehicle control, which could result in death or serious injury. (00008a) See Indicator Lamps: Touring Models.
The speedometer registers miles per hour (U.S. Models) or kilometers per hour (international models) of forward speed. • Tachometer See OPERATING RECOMMENDATIONS section. Do not operate the engine above maximum safe RPM as shown under OPERATION (red zone on tachometer). Lower the RPM by upshifting to a higher gear or reducing the amount of throttle.
- by admin